Car Checks(PVT)Ltd.
  55/1 Sunethradevi Road,
  Kohuwala,
  Sri Lanka.
  Phone : 2819333,2819335
  Hotline: 0728353535
  Fax:2819334
  E-mail : appointment@carchecksonline.com

96.49
100

VEHICLE INSPECTION SHEET - 1 of 5
Messrs :       Dayan Fernando
This report is confidential and for guidance of address only. And is not to be used for any other purpose or distribute to any other party or be published in any form. Inspection is necessarily superficial and no dismantling nor reassembling of any mechanism implied nor accepted.
   
Time of Inspection 08/24/2019 08:27 AM Place of Inspection Car Checks
Primary vehicle details:
Registration No WP CBD-5777 Year of Manufacture
Country of Origin Japan Vehicle Make Mazda
Model RX7 Chassis Number FD3S-404962
Fuel Type Petrol
Engine model Body Colour (Repainted) Black
Engine Replaced No Odometer Reading 82195km
No of seats 04
Roof Standard Wheel Condition Good
Windscreen cracked No Alterations Yes
Accidents No Air Conditioning Good
Interior:
Interior Type Leather Interior Condition Medium
Interior Plastics Bad Power Steering Good
Electric Seats None Seat Belts Good
Air Bags Good Number of Air Bags 1
Standard Mirrors Good Power Mirrors Good
Fold Mirrors None Central Lock Good
Power Shutters Good Sun Roof None
Interior Lights Not Functioning Meters Functioning
Self Starter Good Horn Good
Reverse Sensor None Reverse Camera None
Climate Control None Automatic Door None
Dual A/C None
Comments RMV chassis number: CMT18013 Comments Drivers side map light not functioning
Front seats reupholstered
Power antenna not functioning
AC vents broken
  Car Checks(PVT)Ltd.
  55/1 Sunethradevi Road,
  Kohuwala,
  Sri Lanka.
  Phone : 2819333,2819335
  Hotline: 0728353535
  Fax:2819334
  E-mail : appointment@carchecksonline.com
VEHICLE INSPECTION SHEET - 2 of 5
Type of Vehicle Coupe
Driving System RF
Number of Doors 2
Roof Standard
Wheel Type Alloy
Tyre wear(%) Front: Left:10 Right:10
Rear: Left: 10 Right:10
Comments Tires mismatched
Mechanical 56.99% out of 60.00%
Engine 8.143% out of 8.571%
Suspension 8.095% out of 8.571%
Steering 6.857% out of 8.571%
Brakes 8.182% out of 8.571%
Transmission 8.571% out of 8.571%
Cooling 8.571% out of 8.571%
Exhaust 8.571% out of 8.571%
96.49% out of 100%
Body/Chassis 25.00% out of 25.00%
Pillars 12.50%out of 12.50%
Box-Joints 12.50% out of 12.50%
Exterior 10.00% out of 10.00%
Exterior 10.00% out of 10.00%
Tyre wear 4.50% out of 5.00%
Tyre wear 4.50% out of 5.00%
Exterior .....
Headlights Good
Signal Lights Good
Hazard Warning Lights Good
Brake Lights Good
Park Lights Good
Reverse Lights Good
Fog Lights Good
Windscreen Wipers Good
Windscreen Wiper Mechanism Good
Windscreen Wiper Nozzles Good
Comments Nothing to add.
Body .....
A-Pillar Good
B-Pillar Good
C-Pillar None
D-Pillar None
Comments Face lift front bumper, spoiler and tail lights fitted
Subframe
1-BoxJoint Good
2-BoxJoint Good
3-BoxJoint Good
Comments Rear right side valance area damaged and repaired (non structural)
  Car Checks(PVT)Ltd.
  55/1 Sunethradevi Road,
  Kohuwala,
  Sri Lanka.
  Phone : 2819333,2819335
  Hotline: 0728353535
  Fax:2819334
  E-mail : appointment@carchecksonline.com
VEHICLE INSPECTION SHEET - 3 of 5
Braking System
ABS Good
Hand Brake Good
Brake Fluid Bad
Master Pump Good
Brake Servo Good
Front Brake Hoses Good
Front Brake Discs Good
Front Brake Pads Good
Front Brake Drums None
Front Brake Shoes None
Rear Brake Hoses Good
Rear Brake Discs Good
Rear Brake Pads Good
Rear Brake Drums None
Rear Brake Shoes None
Brake Padal Rubber Good
Brake Light Switch Good
Brake Oil Reservoir Good
Front Brake Caliper Pins Good
Rear Brake Caliper Pins Good
Front Brake Caliper Washers Good
Rear Brake Caliper Washers Good
Front Brake Caliper Pistons Good
Rear Brake Caliper Pistons Good
Front Brake Binding No
Rear Brake Binding No
Comments Recommend replacing brake fluid
Engine
Accelerator Pedal Rubber Good
Hybrid System None
Turbo Good
Super Charger None
Throttle Body Good
High tension leads None
Tappet Cover Good
Tappets Good
Head Gasket Good
Misfiring No
Cylinder Compression Good
Distributor None
Igniter Coils Good
Alternator Good
Alternator belt Bad
Timing Chain Good
Timing Belt None
Engine Mounts Good
Sump Gasket Good
Push Rods None
Air Filter Good
Air Flow Sensor Good
Induction Housing Good
Camshaft Sensor Good
Camshaft Oil Seal Good
Crankshaft Sensor Good
Crankshaft Oil Seal Good
Burning Oil No
Comments Recommend replacing drive belt
Oil residue present on left side of engine block near spark plugs, recommend cleaning and further inspection by dealer
Oil line to turbo leaking
Aftermarket blow off valve fitted
Steering .....
Steering Box None
Steering Rack Good
Steering Rack-end Good
Tie Rod Good
Lower Ball Joints Good
Upper Ball Joints Bad
Comments Power steering pulley broken
Upper arm ball joint dust boots worn on right side
Cooling System .....
Water Pump Good
Coolant Lines Good
Radiator Good
Radiator Fan Good
Thermostat Good
Radiator Cap Good
Top Tank Good
Bottom Tank Good
Core Good
Comments Nothing to add.
  Car Checks(PVT)Ltd.
  55/1 Sunethradevi Road,
  Kohuwala,
  Sri Lanka.
  Phone : 2819333,2819335
  Hotline: 0728353535
  Fax:2819334
  E-mail : appointment@carchecksonline.com
VEHICLE INSPECTION SHEET - 4 of 5
Transmission .....
Gearbox Good
Gear Selection Good
Gearbox Mounts Good
Shafting Good
Gearbox Shaft(s) Good
Gearbox Cable(s) Good
Gearbox Rasors Good
Gear Engagement Good
Gearbox Oil Good
Continuous Velocity Transmission System None
Clutch Good
Clutch Plate Good
Clutch Pedal Rubber Good
Pressure Plate Good
Release Bearing Good
Clutch Pump Good
Clutch Cables Good
Clutch Pump Fluid Good
Clutch Servo None
Front inner CV Joints None
Front outer CV Joints None
Front Differential None
Front Propeller Shaft None
Front Universal Joints None
Rear inner CV Joints Good
Rear outer CV Joints Good
Rear Differential Good
Rear Propeller Shaft Good
Rear Propeller Shaft Universal Joints Good
Front Drive-shafts None
Front Drive-shaft Oil Seals None
Rear Drive-shafts Good
Rear Drive-shaft Oil Seals Good
Traction Control Good
Active Stability Control Good
Triptronic System None
Economy Mode None
Sport Mode None
Comments Rear CV boots starting to crack
Play present in gear lever, recommend inspection of gear lever bushes
Recommend inspection of differential carrier bushes
Exhaust system .....
Exhaust manifold Good
Connecting Pipe Good
Front Pipe Good
Middle Silencer (Resonator) Good
Catalytic Converter Good
Extension Pipes Good
Flanges Good
Gasket Good
Hangers Good
Clamps Good
Comments Nothing to add.
Suspension .....
Front Swing Arms Good
Front Upper Swing-Arm Bushes Good
Front Lower Swing-Arm Bushes Good
Front Shocks Good
Front Shock Mounts Good
Front Shock Bushes Good
Front Electronic Damping None
Front Coil Springs Good
Front Coil Spring Damping Bad
Front Shock Bumpers Good
Front Lower Forward Torsion Bar Good
Front Lower Forward Torsion Bar Bushes Good
Front Lower Aft Torsion Bar Good
Front Lower Aft Torsion Bar Bushes Good
Front Upper Forward Torsion Bar Good
Front Upper Forward Torsion Bar Bushes Good
Front Upper Aft Torsion Bar Good
Front Upper Aft Torsion Bar Bushes Good
Front Stabilizer Bar Multi-links Good
Front Strut Brace(s) None
Rear Swing Arms Good
Rear Upper Swing-Arm Bushes Good
Rear Lower Swing Arm Bushes Good
Rear Shocks Bad
Rear Shock Mounts Good
Rear Shock Bushes Good
Rear Leaf Springs None
Rear Leaf Spring Bushes None
Rear Electronic Damping None
Rear Coil Springs Good
Rear Coil Spring Damping Good
Rear Shock Bumpers Good
Rear Lower Forward Torsion Bar Good
Rear Lower Forward Torsion Bar Bushes Good
Rear Lower Aft Torsion Bar Good
Rear Lower Aft Torsion Bar Bushes Good
Rear Upper Forward Torsion Bar Good
Rear Upper Forward Torsion Bar Bushes Good
Rear Upper Aft Torsion Bar Good
Rear Upper Aft Torsion Bar Bushes Good
Rear Stabilizer Bar Multi-links Good
Rear Strut Brace(s) None
Comments Rear shock boots cracking
Rear shocks very stiff, recommend dismantle and inspection
Front coil spring damping worn
  Car Checks(PVT)Ltd.
  55/1 Sunethradevi Road,
  Kohuwala,
  Sri Lanka.
  Phone : 2819333,2819335
  Hotline: 0728353535
  Fax:2819334
  E-mail : appointment@carchecksonline.com
VEHICLE INSPECTION SHEET - 5 of 5
Referance Diagram
EXPLANATION OF MARKING

A : Scratch           G : Hole
B : Bend              H : Replaced
C : Corrode          I : Painted
D : Dent
E : Tear
F : Wave
SIZE OF DENT AND SCRATCH

1 : Slight             4 : Large
2 : Small             5 : Heavy
3 : Medium         



REMARKS: This report is governed by, and for your exclusive use. Unless specifically agreed, the relates to the facts as recorded by us within the limits of instructions received and, if appropriate, states it’s opinion based on such facts. In providing our services, we do not take the place of designers, manufactures, producers, operators, transporters, sellers, buyers or owners, who, notwithstanding our actions, are not released from any of their obligations of whatever nature. In particular, our inspection and the resulting report do not release the seller of goods from it’s own obligations toward the buyer of such goods. Any information and recommendations supplied by us shall not be held or construed to amount to approval or acceptance of the items in connection with which the information and recommendations supplied or of their of the quality, merchantability or fitness for any purpose. The above results are valid at the time and place of inspection.