Car Checks(PVT)Ltd.
55/1 Sunethradevi Road,
Kohuwala,
Sri Lanka.
Phone : 2819333,2819335
Hotline: 0728353535
Fax:2819334
E-mail : appointment@carchecksonline.com

82.77
100

VEHICLE INSPECTION SHEET - 1 of 5

Messrs : Shane
This report is confidential and for guidance of address only. And is not to be used for any other purpose or distribute to any other party or be published in any form. Inspection is necessarily superficial and no dismantling nor reassembling of any mechanism implied nor accepted.

Time of Inspection	07/05/2019 08:48 AM	Place of Inspection	Car Checks
Primary vehicle details:
Registration No	WP KB-9882	Year of Manufacture	2002
Country of Origin	Japan	Vehicle Make	Toyota
Model	Premio	Chassis Number	ZZT240-5008139
Fuel Type	Petrol
Engine model		Body Colour (Repainted)	Black
Engine Replaced	No	Odometer Reading	143481km
No of seats	05
Roof	Standard	Wheel Condition	Serviceable
Windscreen cracked	No	Alterations	No
Accidents	Yes	Air Conditioning	Good
Interior:
Interior Type	Cloth	Interior Condition	Medium
Interior Plastics	Bad	Power Steering	Bad
Electric Seats	None	Seat Belts	Good
Air Bags	Good	Number of Air Bags	2
Standard Mirrors	None	Power Mirrors	Good
Fold Mirrors	Good	Central Lock	Bad
Power Shutters	Bad	Sun Roof	None
Interior Lights	Functioning	Meters	Not Functioning
Self Starter	Good	Horn	Bad
Reverse Sensor	None	Reverse Camera	Bad
Climate Control	Bad	Automatic Door	None
Dual A/C	None
Comments	AC modes not functioning Vanity mirror lids missing Horn not functioning Central lock not functioning ABS light active at time of inspecting (intermittent, diagnostic scan does not detect any fault) Oil pressure light active at time of inspection (oil level low at time of inspection, oil was topped up but light was still active) Recommend dealer inspection of fuses, fuse boxes, wiring, wire harness ect. Wire harness sheathing in engine bay split open	Comments	Front power shutters not functioning Radio plastics broken Dash panel plastics broken Center console loose Front left door beading missing (water ingress present) Reverse camera not functioning Fuel gauge not functioning

Car Checks(PVT)Ltd.
55/1 Sunethradevi Road,
Kohuwala,
Sri Lanka.
Phone : 2819333,2819335
Hotline: 0728353535
Fax:2819334
E-mail : appointment@carchecksonline.com

VEHICLE INSPECTION SHEET - 2 of 5

Type of Vehicle	Sedan
Driving System	FF
Number of Doors	4
Roof	Standard
Wheel Type	Alloy
Tyre wear(%)	Front: Left:100 Right:40
Tyre wear(%)	Rear: Left: 0 100 Right:40
Comments	Front left tire worn out Rear left tire expired (2016) Recommend replacing front left and rear left tires Recommend wheel alignment

Mechanical 48.77% out of 60.00%

Engine 6.316% out of 8.571%

Suspension 7.381% out of 8.571%

Steering 6.857% out of 8.571%

Brakes 6.316% out of 8.571%

Transmission 5.714% out of 8.571%

Cooling 7.619% out of 8.571%

Exhaust 8.571% out of 8.571%

82.77% out of 100%

Body/Chassis 25.00% out of 25.00%

Pillars 12.50%out of 12.50%

Box-Joints 12.50% out of 12.50%

Exterior 9.00% out of 10.00%

Tyre wear 0.00% out of 5.00%

Exterior .....
Headlights	Good
Signal Lights	Good
Hazard Warning Lights	Good
Brake Lights	Good
Park Lights	Good
Reverse Lights	Good
Fog Lights	Good
Windscreen Wipers	Bad
Windscreen Wiper Mechanism	Good
Windscreen Wiper Nozzles	Good
Comments	Rear wiper blades damaged Recommend replacing wiper blades

Body .....
A-Pillar	Good
B-Pillar	Good
C-Pillar	Good
D-Pillar	Good
Comments	Front side impact damage (non structural), front bonnet repaired, bumper repaired, right side fender and doors repaired, bonnet removed and refitted. Front left door repaired. Note : AC Compressor replaced, Power steering pump pulley replaced

Subframe
1-BoxJoint	Good
2-BoxJoint	Good
3-BoxJoint	Good
Comments	Rear collision damage (non structural), rear boot floor pan repaired, rear quarter panels repaired, rear bumper replaced, rear boot lid repaired, rear bumper misaligned. Rear bumper damaged. Rear boot lid damaged.

Car Checks(PVT)Ltd.
55/1 Sunethradevi Road,
Kohuwala,
Sri Lanka.
Phone : 2819333,2819335
Hotline: 0728353535
Fax:2819334
E-mail : appointment@carchecksonline.com

VEHICLE INSPECTION SHEET - 3 of 5

Braking System
ABS	Good
Hand Brake	Good
Brake Fluid	Bad
Master Pump	Good
Brake Servo	Good
Front Brake Hoses	Good
Front Brake Discs	Bad
Front Brake Pads	Bad
Front Brake Drums	None
Front Brake Shoes	None
Rear Brake Hoses	Good
Rear Brake Discs	None
Rear Brake Pads	None
Rear Brake Drums	Good
Rear Brake Shoes	Good
Brake Padal Rubber	Good
Brake Light Switch	Good
Brake Oil Reservoir	Good
Front Brake Caliper Pins	Bad
Rear Brake Caliper Pins	None
Front Brake Caliper Washers	Good
Rear Brake Caliper Washers	None
Front Brake Caliper Pistons	Good
Rear Brake Caliper Pistons	None
Front Brake Binding	Yes
Rear Brake Binding	No
Comments	Recommend replacing brake fluid Front brake pads worn Front brake binding present, recommend inspection and servicing of front brake calipers Front brake discs worn

Engine
Accelerator Pedal Rubber	Good
Hybrid System	None
Turbo	None
Super Charger	None
Throttle Body	Good
High tension leads	None
Tappet Cover	Bad
Tappets	Good
Head Gasket	Good
Misfiring	No
Cylinder Compression	Good
Distributor	None
Igniter Coils	Good
Alternator	Bad
Alternator belt	Bad
Timing Chain	Good
Timing Belt	None
Engine Mounts	Bad
Sump Gasket	Good
Push Rods	None
Air Filter	Bad
Air Flow Sensor	Good
Induction Housing	Good
Camshaft Sensor	Good
Camshaft Oil Seal	Good
Crankshaft Sensor	Good
Crankshaft Oil Seal	Good
Burning Oil	No
Comments	Engine is hesitant to start Recommend compression test by dealer Recommend replacing air filter At time of inspection oil level low Engine cover damaged and repaired Starter battery charging rate low, recommend inspection and servicing of starter battery and alternator All engine mounts worn Tappet cover packing leaking

Steering .....
Steering Box	None
Steering Rack	Bad
Steering Rack-end	Good
Tie Rod	Good
Lower Ball Joints	Good
Upper Ball Joints	Good
Comments	Power steering rack leaking Power steering pump leaking

Cooling System .....
Water Pump	Good
Coolant Lines	Good
Radiator	Good
Radiator Fan	Good
Thermostat	Good
Radiator Cap	Good
Top Tank	Good
Bottom Tank	None
Core	Good
Comments	Recommend coolant flush

Car Checks(PVT)Ltd.
55/1 Sunethradevi Road,
Kohuwala,
Sri Lanka.
Phone : 2819333,2819335
Hotline: 0728353535
Fax:2819334
E-mail : appointment@carchecksonline.com

VEHICLE INSPECTION SHEET - 4 of 5

Transmission .....
Gearbox	Good
Gear Selection	Good
Gearbox Mounts	Bad
Shafting	Good
Gearbox Shaft(s)	Good
Gearbox Cable(s)	Good
Gearbox Rasors	Good
Gear Engagement	Good
Gearbox Oil	Bad
Continuous Velocity Transmission System	Good
Clutch	None
Clutch Plate	None
Clutch Pedal Rubber	None
Pressure Plate	None
Release Bearing	None
Clutch Pump	None
Clutch Cables	None
Clutch Pump Fluid	None
Clutch Servo	None
Front inner CV Joints	Bad
Front outer CV Joints	Bad
Front Differential	Good
Front Propeller Shaft	None
Front Universal Joints	None
Rear inner CV Joints	None
Rear outer CV Joints	None
Rear Differential	None
Rear Propeller Shaft	None
Rear Propeller Shaft Universal Joints	None
Front Drive-shafts	Good
Front Drive-shaft Oil Seals	Bad
Rear Drive-shafts	None
Rear Drive-shaft Oil Seals	None
Traction Control	None
Active Stability Control	None
Triptronic System	None
Economy Mode	None
Sport Mode	None
Comments	Gearbox oil overfilled Recommend servicing gearbox Front left outer CV boot torn and leaking CV boots leaking grease, recommend dismantle and inspection of all CV joints All gearbox mounts worn Drive shaft oil seal leaking

Exhaust system .....
Exhaust manifold	Good
Connecting Pipe	Good
Front Pipe	Good
Middle Silencer (Resonator)	Good
Catalytic Converter	Good
Extension Pipes	Good
Flanges	Good
Gasket	Good
Hangers	Good
Clamps	Good
Comments	Nothing to add.

Suspension .....
Front Swing Arms	Good
Front Upper Swing-Arm Bushes	Good
Front Lower Swing-Arm Bushes	Bad
Front Shocks	Good
Front Shock Mounts	Good
Front Shock Bushes	Good
Front Electronic Damping	None
Front Coil Springs	Good
Front Coil Spring Damping	Bad
Front Shock Bumpers	Bad
Front Lower Forward Torsion Bar	Good
Front Lower Forward Torsion Bar Bushes	Good
Front Lower Aft Torsion Bar	Good
Front Lower Aft Torsion Bar Bushes	Good
Front Upper Forward Torsion Bar	Good
Front Upper Forward Torsion Bar Bushes	Good
Front Upper Aft Torsion Bar	Good
Front Upper Aft Torsion Bar Bushes	Good
Front Stabilizer Bar Multi-links	Good
Front Strut Brace(s)	None
Rear Swing Arms	Good
Rear Upper Swing-Arm Bushes	Good
Rear Lower Swing Arm Bushes	Bad
Rear Shocks	Good
Rear Shock Mounts	Good
Rear Shock Bushes	Good
Rear Leaf Springs	None
Rear Leaf Spring Bushes	None
Rear Electronic Damping	None
Rear Coil Springs	Good
Rear Coil Spring Damping	Good
Rear Shock Bumpers	Bad
Rear Lower Forward Torsion Bar	Good
Rear Lower Forward Torsion Bar Bushes	Good
Rear Lower Aft Torsion Bar	Good
Rear Lower Aft Torsion Bar Bushes	Good
Rear Upper Forward Torsion Bar	Good
Rear Upper Forward Torsion Bar Bushes	Good
Rear Upper Aft Torsion Bar	Good
Rear Upper Aft Torsion Bar Bushes	Good
Rear Stabilizer Bar Multi-links	Good
Rear Strut Brace(s)	None
Comments	Front and rear lower arm bushes cracking Front shock bumpers worn Front shock boots worn Rear shock boots worn Front coil spring dampening worn Recommend dismantle and inspection of all shocks

Car Checks(PVT)Ltd.
55/1 Sunethradevi Road,
Kohuwala,
Sri Lanka.
Phone : 2819333,2819335
Hotline: 0728353535
Fax:2819334
E-mail : appointment@carchecksonline.com

VEHICLE INSPECTION SHEET - 5 of 5

Referance Diagram

EXPLANATION OF MARKING

A : Scratch           G : Hole
B : Bend              H : Replaced
C : Corrode          I : Painted
D : Dent
E : Tear
F : Wave

SIZE OF DENT AND SCRATCH

1 : Slight             4 : Large
2 : Small             5 : Heavy
3 : Medium

REMARKS: This report is governed by, and for your exclusive use. Unless specifically agreed, the relates to the facts as recorded by us within the limits of instructions received and, if appropriate, states it’s opinion based on such facts. In providing our services, we do not take the place of designers, manufactures, producers, operators, transporters, sellers, buyers or owners, who, notwithstanding our actions, are not released from any of their obligations of whatever nature. In particular, our inspection and the resulting report do not release the seller of goods from it’s own obligations toward the buyer of such goods. Any information and recommendations supplied by us shall not be held or construed to amount to approval or acceptance of the items in connection with which the information and recommendations supplied or of their of the quality, merchantability or fitness for any purpose. The above results are valid at the time and place of inspection.

82.77 100

82.77
100